Newer transmissions that are referred to as 4R70E or 4R75E have modifications that compliment Fords switching to throttle by wire. Place a drain pan of sufficient capacity under the radiator and open the petcock drain on the radiator. Similar to most automatic overdrive transmissions of that time, this transmission incorporates a case of aluminum construction, a fully electronic valve body and a lockup torque converter. Frequent fluid changes, especially when used for towing, are the single best method to prevent shudder. Raise and support the vehicle.
The swivel makes it easier to clear the firewall. It was also used in the F-series pickup trucks, including. The front four connect the covering to the frame. These modifications are specified by one of the Ford engineers who designed the transmission. The driver side bolt is located in the same area but below the Air Intake filter compartment.
The coolant level should go down, this is normal as the system bleeds the air pockets out of the system. This transmission unit includes a transmission case, valve body, tail shaft and housing, torque converter automatic only , and all internal lubricated parts. The transmission featured a split-torque application for third gear as well as a lockup in the torque converter. This transmission unit includes a transmission case, valve body, tail shaft and housing, torque converter automatic only , and all internal lubricated parts. Next you can actually remove the plugs. Remove the recovery tank or radiator cap.
The new water-pump installed and bolted tight. This includes both cars and trucks. Apply some dielectric grease to the plug boots as well to help seal them. Step 9 - Use the coarse side of the sponge to clean the water pump opening. Jack up your truck and safely support using jack stands! There are 15 choices for the 2000 Ford F-150 Transmission Assembly!!! The yellow plastic protector pictured, your might be a different color should be removed. Carefully remove the bolts that hold the transmission case to the engine block.
This transmission unit has been inspected, tested and ready to ship. The threads in the aluminum heads have enough problems as it is. These improvements allowed the 4R75W to handle more power while being more efficient and economical. In 1998, due to durability concerns, the intermediate one-way roller clutch was replaced with a mechanical diode providing extra holding capacity and longer service. Browse our online catalog and. Once the bolts are out, you will probably need to use a hammer and a block of wood, or just a hammer to beat the water pump out of the engine.
Leave the recovery tank or radiator cap off to aid in bleeding the system. This usually results in the death of the transmission fairly quickly. I take an old piece of seat foam and put it on top of the radiator support to the engine to allow me to lay on it without hurting my tummy. It makes the job way less painful. We highly recommend doing so with a over one that was simply rebuilt. Customers could order from a number of different cab designs, including an extended cab that could hold up to six people. Step 7 - Using the 10mm sockets, loosen the four bolts of the fan pulley.
I've replaced plugs on quite a few 5. Until Step 6 is complete. While these modifications can be done to 4R75W transmission, the results are not as dramatic as some of the details of the J-Mod bigger holes in the separator plate and gasket were done to the transmission in its design. The other transmission is the 4R100, and has a drain plug in the pan. It should separate from the engine easily.
Introduced in 1980, it was 's first four-speed automatic overdrive transmission. This transmission unit has been inspected, tested and ready to ship. Lower it to the ground with the torque converter installed. Refill the system with coolant to the proper level. The Ford F150, equipped with the 4R70W transmission. You can use a piece of vacuum hose or fuel hose over the end of the plug to get it started in the hole. Once on the ground, slide the transmission out and away from the bottom of your truck.